Researchers Moving Closer to Creating Viable Energy From Sewage

Oct 08, 2008

( -- When a newly developed technology for producing hydrogen gas from biowaste is brought to commercial use – as researchers believe it can be – then it appears the world will have plenty of energy if it can just solve the stubborn shortage of sewage.

A new approach has been developed to use several types of biowaste, including ordinary municipal sewage, to produce hydrogen at a much lower cost than the traditional “electrolysis” technology, and make it more viable for use in the hydrogen fuel cells that many believe will power automobiles of the future.

The findings have just been reported in Water Research, a professional journal, by researchers in the College of Engineering at Oregon State University.

Studies suggest that this approach could reduce the amount of energy needed to produce hydrogen by as much as 75 percent, compared with hydrogen production by water electrolysis. More work needs to be done to reduce the cost for electrode materials and more advances in efficiency are possible, experts say.

"In the laboratory we're already quite close to the Department of Energy hydrogen cost goal of $2 to $3 per gasoline gallon equivalent, or GGE," said Hong Liu, an OSU assistant professor of biological and ecological engineering. "And with some additional research it should be possible to scale these systems up to levels needed for commercial use."

But that's not even the best news, Liu said.

While it's producing significant amounts of hydrogen from sewage, this system also cleans the water. Conceptually, treatment plants could be developed that take in sewage on one end and send clean water and hydrogen fuel out the other. Their production potential may only be limited by the amount of raw waste they have available – and sewage in the future may no longer be a waste disposal problem but rather a valued commodity, another important component of the nation's sustainable energy equation.

Other forms of biowaste could also be used, scientists say. The use of woody biomass is possible. The large amounts of waste from food processing factories would be a good candidate, as well as agricultural waste such as the huge amounts of manure produced in cattle, hog, and other livestock operations. In that context, it may be quite possible to make a silk purse out of a sow's rear.

All of this was achieved through fundamental research on "microbial electrolysis cells," or MECs, that use a new "membrane free" approach that costs less and is significantly more efficient than existing approaches.

"The removal of membrane not only can simplify the construction, operation and maintenance of MECs, but it also can decrease the internal resistance, thus increase the hydrogen production rate," the researchers said in their report.

In these systems, naturally occurring microorganisms from sewage attach to the surface of an anode and degrade the waste in the sewage, in a device that is something like a battery. The waste decomposes, eventually leaving protons that migrate to the cathode, combine with electrons and generate hydrogen.

These systems can be adapted to generate electricity directly or used to produce hydrogen, which in turn can be used to produce electricity from hydrogen fuel cells – an existing and widely proven technology.

"Hydrogen has often been thought of as the ideal fuel to run fuel-cell powered automobiles," Liu said. "Hydrogen fuel cells are about 60 percent efficient, roughly double that of a gasoline internal combustion engine. And there is no air pollution; the only byproduct from operation of the fuel cell is water."

One of the biggest steps still needed to make this type of fuel cell vehicle a reality is solving hydrogen production issues – and the new technology developed in Liu's laboratory might produce hydrogen at a cost close to the DOE goal. Those cost figures do not include the potential savings of billions of dollars spent in treating the nation's wastewater, which further increase the economical viability of the technology.

"Another interesting application of this approach might be in developing countries or remote areas," Liu said. "Often these places have few or no waste treatment plants, and no practical way in a remote location to produce electricity. Small systems used there might solve both problems.

"There's no doubt this could help contribute to a more sustainable future," Liu said. "We could clean up our sewage and produce fuel at the same time. That's very promising."

Provided by Oregon State University

Explore further: Biogas to biomethane upgrading by water absorption column at low pressure and temperature

Related Stories

Fuel and chemicals from steel plant exhaust gases

4 hours ago

Carbon monoxide-rich exhaust gases from steel plants are only being reclaimed to a minor extent as power or heat. Fraunhofer researchers have developed a new recycling process for this materially unused carbon resource: They ...

UW researchers scaling up fusion hopes

Jun 02, 2015

Producing reliable fusion energy—the same process that powers the sun—has long been a holy grail of scientists here on Earth. It releases no greenhouse gases, can be fueled by elements found in seawater ...

Recommended for you

Vehicle fuel economy down, emissions up

8 hours ago

Gas mileage of new vehicles sold in the U.S. slipped last month, according to researchers at the University of Michigan Transportation Research Institute.

A bridge to better batteries

8 hours ago

A major automaker came to Lawrence Berkeley National Laboratory recently wanting to better understand battery degradation. After many months of intense collaborative research with a Berkeley Lab battery scientist, ...

User comments : 7

Adjust slider to filter visible comments by rank

Display comments: newest first

4.5 / 5 (2) Oct 08, 2008
Do your part and drop your pants lol!
not rated yet Oct 08, 2008
My IBS is good for something finally!
5 / 5 (1) Oct 08, 2008
I would like to know just how abundant those "resources" are and how much hydrogen could be produced from them annually given the required elecrticity is available? Could this technology replace other fuels for transportation or merely assist existing technologies?
1.5 / 5 (2) Oct 08, 2008
how much fossel fuels will it take to make a gge?

like the mythical bio fuels....
4.5 / 5 (2) Oct 08, 2008
The service station toilet yields both hydrogen and methane. Both burn fine! It's a winner!
5 / 5 (2) Oct 08, 2008
It only needs to provide enough energy to offset some of the cost of conventional sewage treatment to be an important development.

Since C02 would be released, might it be captured and purified for industrial purposes? Or would that add too much complexity to the system to justify the effort?
not rated yet Nov 17, 2008
This is being done already, albeit a different process than using fuel cells:

Please sign in to add a comment. Registration is free, and takes less than a minute. Read more

Click here to reset your password.
Sign in to get notified via email when new comments are made.