Identifying the origin of macroscopic friction between clay mineral surfaces

January 25, 2019, National Institute for Materials Science
We removed moisture from the space between the muscovite surfaces by applying high pressure under dry conditions. We then measured frictional forces between the muscovite surfaces at different sliding positions. The results of this experiment closely coincided with frictional forces estimated using quantum mechanical calculations, indicating that the frictions occurring between clay minerals are controlled by atomic-scale electrostatic forces. Credit: NIMS

NIMS, the University of Tokyo and Hiroshima University jointly discovered for the first time, through theoretical calculation and experiment, that macroscopic frictions occurring between clay mineral surfaces originate from interatomic electrostatic forces between these surfaces. This finding may facilitate the design of solid lubricant materials and understanding of earthquake-causing fault slip mechanisms.

Frictional forces between the surfaces of layered crystals, such as minerals, are generally low. This property is thought to be a cause of landslides and fault movements in nature. Active efforts have been made in research on friction to develop friction-reducing solid lubricants and for other purposes. Origin of Friction between clay surfaces had been thought to be induced by some sorts of bonding forces; however, these forces were not understood in detail due to complex influences of electrostatic and intermolecular forces between clay mineral surfaces, crystallographic orientation differences between these surfaces, roughness and the presence of impurities.

This joint research team studied muscovite—a layered clay mineral—with flat and smooth surfaces at the atomic level. The team first removed moisture from the space between the muscovite surfaces (20 cm x 40 cm in area) by applying high pressure under dry conditions. The team then measured frictional forces between the muscovite surfaces at different sliding positions. As a result, the team observed wear particles produced from worn muscovite surfaces and found that these particles may have nullified the effect of crystallographic orientation on frictional forces. The team also determined the frictional forces generated by estimating interatomic electrostatic forces between contacting surfaces using quantum mechanical calculations, assuming that the effect of crystallographic orientation on frictional forces is null. The calculated frictional forces nearly perfectly matched experimental results. Thus, the research team confirmed for the first time that frictions occurring between the surfaces of clay minerals of tens of centimeters in size are controlled by atomic-scale electrostatic forces.

In future studies, the researchers hope to develop a theory that will explain frictional strength in a broad range of clay minerals, in addition to muscovite. Such theory may provide material design guidelines for friction-reducing solid lubricants and other friction-related products.

Explore further: New study challenges centuries-old Amontons' laws of friction

More information: H. Sakuma et al, What is the origin of macroscopic friction? Science Advances (2018). DOI: 10.1126/sciadv.aav2268

Related Stories

Study yields a new scale of earthquake understanding

June 27, 2018

Nanoscale knowledge of the relationships between water, friction and mineral chemistry could lead to a better understanding of earthquake dynamics, researchers said in a new study. Engineers at the University of Illinois ...

Controlling friction by tuning van der Waals forces

July 19, 2013

For a car to accelerate there has to be friction between the tire and the surface of the road. The amount of friction generated depends on numerous factors, including the minute intermolecular forces acting between the two ...

Recommended for you

Coffee-based colloids for direct solar absorption

March 22, 2019

Solar energy is one of the most promising resources to help reduce fossil fuel consumption and mitigate greenhouse gas emissions to power a sustainable future. Devices presently in use to convert solar energy into thermal ...

Physicists reveal why matter dominates universe

March 21, 2019

Physicists in the College of Arts and Sciences at Syracuse University have confirmed that matter and antimatter decay differently for elementary particles containing charmed quarks.

ATLAS experiment observes light scattering off light

March 20, 2019

Light-by-light scattering is a very rare phenomenon in which two photons interact, producing another pair of photons. This process was among the earliest predictions of quantum electrodynamics (QED), the quantum theory of ...

How heavy elements come about in the universe

March 19, 2019

Heavy elements are produced during stellar explosion or on the surfaces of neutron stars through the capture of hydrogen nuclei (protons). This occurs at extremely high temperatures, but at relatively low energies. An international ...

0 comments

Please sign in to add a comment. Registration is free, and takes less than a minute. Read more

Click here to reset your password.
Sign in to get notified via email when new comments are made.