Energy efficient sewage plants

August 13, 2009

High-rate digestion with microfiltration is state-of-the-art in large sewage plants. It effectively removes accumulated sludge and produces biogas to generate energy. A study now reveals that even small plants can benefit from this process.

Sewage plants remove organic matter from . If the accumulating sludge decays, biogas is generated as a by-product. However, only 1156 of the 10,200 sewage plants in Germany have a digestion tank. Smaller operations, especially, baulk at the costs of a new digestion tank. Instead, they enrich the sludge with oxygen in the existing activation basin, and stabilize it.

"Activation basins require a lot of electricity. At the same time, enormous energy potential is lost, since no biogas is produced," says Dr. Brigitte Kempter-Regel of the Fraunhofer Institute for Interfacial Engineering and Biotechnology IGB in Stuttgart. "A sewage plant eats up more electricity in the municipalities than their hospitals do".

In a cost-benefit-study Dr. Kempter-Regel has shown that it also pays small sewage plants to transfer to more energy-efficient processes - even if they have to invest in a sludge digestion unit. "Based on a sewage plant for 28,000 inhabitants, we calculate that the plant can reduce its annual waste management costs from 225,000 euros by as much as 170,000 euros if sludge is decayed in a high-rate digestion unit with microfiltration, as opposed to treating it aerobically", she says.

This process was developed at IGB and is much more effective than conventional digestion. Instead of the usual 30 to 50 days, sludge only remains in the tower for five to seven days. Around 60 percent of the organic matter is converted into biogas - the spoil is approximately a third more than in the traditional digestion process. The biogas obtained can be used to operate the plant, which, in the case study, would cut by at least 70,000 euros each year. High-rate digestion has the added advantage of producing less residual sludge needing disposal.

"This saves the operator another 100,000 euros", says Kempter-Regel. In addition to high energy prices, budgets are also being hit hard by increasing waste management costs. The use of residual sludge in agriculture is controversial, and slurry can no longer be disposed of on landfills; burning the sludge is a very expensive alternative. So an effective reduction of sludge through digestion pays off. Even small sewage plants have already followed the recommendation of the Stuttgart Institute and converted to the high-rate digestion process.

Source: Fraunhofer-Gesellschaft (news : web)

Explore further: 'If a Package Stinks, It Belongs to Me'

Related Stories

'If a Package Stinks, It Belongs to Me'

December 8, 2006

The county of Los Angeles may not like this distinction, but Virginia Tech environmental engineer John Novak says the sludge from this area of California has the “worst odor of any I have ever tested.” A walk inside his ...

Antibiotic resistant bacteria found in fertilizer

May 29, 2009

Vancomycin resistant enterococci (VRE) have been found in sewage sludge, a by-product of waste-water treatment frequently used as a fertilizer. Researchers writing in the open access journal Acta Veterinaria Scandinavica ...

LA to turn sludge into electricity

April 6, 2007

Los Angeles wants to turn wastewater sludge into energy using a process that would cut greenhouse emissions and reduce truck traffic.

Too much nanotechnology may be killing beneficial bacteria

April 29, 2008

Too much of a good thing could be harmful to the environment. For years, scientists have known about silver’s ability to kill harmful bacteria and, recently, have used this knowledge to create consumer products containing ...

Wastewater may be a valuable energy source

September 21, 2004

The energy stored in Toronto's municipal wastewater could be harnessed to run water treatment facilities and contribute power to the city grid, says new University of Toronto research. The study, published in the August ...

Electricity from straw

February 3, 2009

Researchers have developed the first-ever biogas plant to run purely on waste instead of edible raw materials -- transforming waste into valuable material. The plant generates 30 percent more biogas than its predecessors. ...

Recommended for you

US faces moment of truth on 'net neutrality'

December 14, 2017

The acrimonious battle over "net neutrality" in America comes to a head Thursday with a US agency set to vote to roll back rules enacted two years earlier aimed at preventing a "two-speed" internet.

The wet road to fast and stable batteries

December 14, 2017

An international team of scientists—including several researchers from the U.S. Department of Energy's (DOE) Argonne National Laboratory—has discovered an anode battery material with superfast charging and stable operation ...

FCC votes along party lines to end 'net neutrality' (Update)

December 14, 2017

The Federal Communications Commission repealed the Obama-era "net neutrality" rules Thursday, giving internet service providers like Verizon, Comcast and AT&T a free hand to slow or block websites and apps as they see fit ...

0 comments

Please sign in to add a comment. Registration is free, and takes less than a minute. Read more

Click here to reset your password.
Sign in to get notified via email when new comments are made.