Some Chinese coal ash too radioactive for reuse

Some Chinese coal ash too radioactive for reuse
Coal ash from China's high-uranium coal deposits, such as what is produced by this power plant, is too radioactive to be reused in building materials, a new study shows. Credit: Shifeng Dai

Manufacturers are increasingly using encapsulated coal ash from power plants as a low-cost binding agent in concrete, wallboard, bricks, roofing and other building materials. But a new study by U.S. and Chinese scientists cautions that coal ash from high-uranium deposits in China may be too radioactive for this use.

"While most coals in China and the U.S. have typically low uranium concentrations, in some areas in China we have identified coals with high uranium content," said Avner Vengosh, professor of geochemistry and water quality at Duke University's Nicholas School of the Environment. "Combustion of these coals leaves behind the uranium and radium and generates coal ash with very high levels of ."

The level of radiation in this coal ash could pose human health risks, particularly if it is recycled for use in residential , he said.

Some of the coal ash samples analyzed in the new study contained more than 43 times higher than the maximum safe limit established for residential materials by the United Nations Scientific Committee on the Effects of Atomic Radiation.

"The magnitude of radiation we found in some of the Chinese coal ash far exceeds safe standards for radiation in building materials," said Shifeng Dai, professor of geochemistry at the state key laboratory of and safe mining at China University of Mining and Technology (CUMT) in Beijing and Xuzhou, China. "This calls into question the use of coal ash originating from uranium-rich coals for these purposes."

Vengosh, Dai and their teams published their findings Nov. 8 in the peer-reviewed journal Environmental Science and Technology.

The new paper is part of an ongoing collaboration between researchers at CUMT, Duke and Duke Kunshan University to identify the environmental impacts of coal and coal ash in China. Vengosh holds a secondary faculty appointment at Duke Kunshan, which is in China.

To conduct their study, the scientists measured naturally occurring radioactivity in high-uranium coals from 57 sites in China. They also measured radiation levels in coal ash residues produced from this coal, and in soil collected from four sites.

"By comparing the ratio of uranium in the coal to the radioactivity of the coal ash, we identified a threshold at which uranium content in coal becomes too high to allow coal ash produced from it to be used safely in residential building construction," said Nancy Lauer, a Ph.D. student at Duke's Nicholas School, who led the research.

This threshold—roughly 10 parts per million of uranium— is applicable to high-uranium coal deposits worldwide, not just in China, "and should be considered when deciding whether to allow coal ash to be recycled into building materials," she said.

All radionuclide measurements of coal and samples were conducted in Vengosh's lab at Duke.

"Since our findings demonstrate that using ash from this high-uranium is not suitable in building materials, the challenge becomes, how do we dispose of it in ways that limit any potential water or air contamination," Vengosh said. "This question requires careful consideration."


Explore further

Radioactive contaminants found in coal ash

More information: Nancy Lauer et al, Naturally Occurring Radioactive Materials in Uranium-Rich Coals and Associated Coal Combustion Residues from China, Environmental Science & Technology (2017). DOI: 10.1021/acs.est.7b03473
Provided by Duke University
Citation: Some Chinese coal ash too radioactive for reuse (2017, November 9) retrieved 23 April 2019 from https://phys.org/news/2017-11-chinese-coal-ash-radioactive-reuse.html
This document is subject to copyright. Apart from any fair dealing for the purpose of private study or research, no part may be reproduced without the written permission. The content is provided for information purposes only.
608 shares

Feedback to editors

User comments

Nov 09, 2017
But fear not!

These findings aren't likely stop this supplementary material from finding its way into the supply of finished goods.

Reason being that this ash is a waste product, and very cheap, indeed, which lowers the cost of production significantly. And what does lower production cost result in?

You guessed it: more profit$$$$!!!

And in a globalist capitalist economy, safety is at best a secondary consideration to profitability.

Probably it were best if the little pigs went back to building their homes of sticks and straw, rather than have the Big, Bad Wolf microwave their asses right where they live.


Nov 10, 2017
If this is what's left in the furnace, how much has gone up the stacks, to be blown to the winds? Not just Chinese coal, bust most of the world's coal contains some degree of heavy metals, from uranium and thorium to mercury, lead, and cadmium.
I would rather live next door to a nuke than a hundred miles downwind of a coal powerplant.

Nov 12, 2017
How do these levels compare with those of my granite counter tops?

Please sign in to add a comment. Registration is free, and takes less than a minute. Read more