Brighten up! Paint study could save states millions

Mar 10, 2009

A new study from North Carolina State University shows that painted road markings, such as the lines separating traffic lanes, are significantly better at reflecting headlights in the direction that the paint was applied. This finding will help determine how states comply with new federal safety regulations and save money on painting their roadways.

The NC State researchers found that "retroreflectivity values" are higher in the direction of paint striping. "In other words," study co-author Dr. Joe Hummer says, "the paint reflects more light if you are following the painting truck than if you are driving from the other direction." This is a big deal, in part, because approximately 60 percent of the nation's roads are marked with paint, rather than thermoplastics or other materials. Hummer notes that paint "is expensive - two to three thousand dollars per mile of road." Hummer is a professor of civil engineering at NC State. His co-authors are fellow professor Dr. William Rasdorf and Ph.D. student Guanghua Zhang.

Hummer says the research could help state transportation departments better predict how long the painted markings will perform properly - and when they'll need to be replaced. If a state can re-paint every three years instead of every two, it will save a lot of money, Hummer says.

In addition, the new research could play an important role in helping state and federal determine how to measure compliance with upcoming standards on pavement marking brightness. The is expected to release the standards soon, but this new research raises the possibility that a painted line in the road could pass a new brightness standard going in one direction, but fail it if tested from the other direction. This is a question that will have to be resolved in order to ensure uniform compliance with the new standards.

The difference in retroreflectivity, depending on the direction one is driving, is equivalent to about a year of wear and tear. In other words, a painted line in the road will look one year newer if you are driving in the same direction that the paint was applied.

Hummer explains that this happens because glass beads are scattered onto freshly painted traffic markings in order to make them reflective. Because the painting truck is moving, those beads tend to bounce and roll before coming to rest. "The beads skid and build up paint on one side," Hummer says. "Therefore, they are less reflective in that direction."

More information: The research was published in the journal Public Works Management & Policy.

Source: North Carolina State University

Explore further: Physicists create tool to foresee language destruction impact and thus prevent it

add to favorites email to friend print save as pdf

Related Stories

'Hidden' Van Gogh painting revealed

Jul 30, 2008

A new technique allows pictures which were later painted over to be revealed once more. An international research team, including members from Delft University of Technology (The Netherlands) and the University ...

Study to make public roads safer for farmers, drivers

Nov 18, 2008

Population growth and significant increases in development across the country are leading to changes in traffic and driving behavior in many areas where motorists share the road with farmers moving their equipment – changes ...

Toll road privatization may result in indirect impacts

Jan 14, 2008

Privatizing toll roads in the U.S. may result in significant diversions of truck traffic from privatized toll roads to "free" roads, and may result in more crashes and increased costs associated with use of other roads, according ...

Researchers discover Maya mask splendor

Jan 23, 2008

Ancient Mayan temple builders discovered and used lustrous pigments to make their buildings dazzle in the daylight, a Queensland University of Technology researcher has discovered.

Recommended for you

Affirmative action elicits bias in pro-equality Caucasians

10 hours ago

New research from Simon Fraser University's Beedie School of Business indicates that bias towards the effects of affirmative action exists in not only people opposed to it, but also in those who strongly endorse equality.

Election surprises tend to erode trust in government

Jul 24, 2014

When asked who is going to win an election, people tend to predict their own candidate will come out on top. When that doesn't happen, according to a new study from the University of Georgia, these "surprised losers" often ...

Awarded a Pell Grant? Better double-check

Jul 23, 2014

(AP)—Potentially tens of thousands of students awarded a Pell Grant or other need-based federal aid for the coming school year could find it taken away because of a mistake in filling out the form.

User comments : 0