Deadly crashes spur calls for tractor-trailer side guards

July 30, 2017 by Mary Esch
This June 29, 1967, file photo shows the mangled car that actress Jayne Mansfield died in after colliding with a truck, on Route 90 outside of New Orleans. Fifty years after Mansfield car slammed underneath a tractor-trailer, auto safety advocates say hundreds of similar deaths annually could be prevented by guard rails mounted beneath trucks. New York Sen. Charles Schumer has called on federal regulators to require truck underride guards after two cars skidded under a jackknifed milk tanker in northern New York earlier this month. (AP Photo/File)

Fifty years after actress Jayne Mansfield died in a Buick that slammed underneath a tractor-trailer, auto safety advocates say regulations inspired by that gruesome crash need updating to prevent hundreds of similar deaths annually.

"We're asking Congress to pass a bill that would mandate comprehensive underride protection, not only on tractor-trailers but on single-unit trucks," such as dump trucks, said Marianne Karth, who lost two teenage daughters, AnnaLeah and Mary, when her Crown Victoria crashed beneath a tractor-trailer in Georgia in 2013.

After two cars skidded under a jackknifed milk tanker truck in northern New York on July 6, killing four people, U.S. Sen. Charles Schumer called on federal regulators to order big trucks to be equipped with side guards that would prevent cars from sliding beneath them in a .

"The devastation of crashes like these—a result of a gap in truck safety standards—could be reduced," Schumer, a Democrat, said.

According to the Insurance Institute for Highway Safety, 301 of the 1,542 car occupants killed in collisions with a tractor-trailer in 2015 died when their vehicle struck the side of the rig. Another 292 died when their vehicle struck the rear. The institute's researchers estimate that half the fatal crashes between large trucks and passenger vehicles involve underride, which makes air bags and other crash protection ineffective because the top half of the car is sheared off.

Under regulations enacted following Mansfield's death, big rigs are required to have rear underride guards to keep cars from traveling beneath the back of a trailer in a collision. Known as "Mansfield bars," they consist of two vertical steel bars supporting a horizontal bar less than 2 feet (61 centimeters) from the ground.

Side guards aren't required by federal regulations, but at least three cities—Boston, New York and Seattle—mandate them on city-owned trucks to eliminate deaths and injuries, particularly among pedestrians and bicyclists.

The Insurance Institute for Highway Safety says side guards could prevent hundreds of deaths per year in the U.S. This spring, the institute crashed a car into a trailer equipped with a side guard called AngelWing, a steel rail covered with fiberglass. The car's front end crumpled but the test dummy was protected by the and seat belt. Without the guard, the passenger compartment was sheared off, causing devastating head injuries to the dummy.

Karth and Lois Durso, whose 26-year-old daughter Roya died in a side underride crash in Indiana in 2004, have been working together to lobby Congress and the Department of Transportation for a side guard requirement as well as stronger rear guards. Their proposed legislation has no sponsor yet.

"They talked about side underride protection in 1969, but nobody has pursued it relentlessly," Karth said. "I wish somebody would have done it so maybe our daughters would still be here."

Before it issued is last set of regulations for rear-impact guards in 1996, the National Highway Traffic Safety Administration said it had determined that side-underride countermeasures were not cost-effective.

The trucking industry supports other efforts to avoid crashes, such as automatic emergency braking and collision warning systems, said Sean McNally, spokesman for the American Trucking Associations. But the industry is looking to the National Highway Traffic Safety Administration to address questions about the effectiveness of side underride guards, he said.

The Truck Trailer Manufacturers Association said in comments submitted to the National Highway Traffic Safety Administration in May 2016 that there are no side impact guards commercially available for installation on trailers. The trade group said "customer demand is non-existent" due to the "relatively low frequency of side underride accidents," the significant added cost and weight per trailer for designs that had been evaluated, and "many unresolved technical challenges."

One consequence of adding the extra weight of guards to trailers would be displacement of cargo onto additional trailers, which would add more heavy trucks to the highways and increase the risk of all types of accidents, said John Freiler, engineering manager of the manufacturers association.

In the northern New York crash, a milk tanker truck jackknifed across both lanes of Interstate 81 when the driver swerved to avoid hitting deer. Two cars skidded beneath and beyond the tanker, killing a doctor in one car and three workers riding in another car after their ambulance broke down.

R.B. Lawrence, owner of the ambulance company that lost three employees, said he'd like to see safety measures to prevent similar tragedies, but he's not sure if the best solution is underride guards or improved braking technology to prevent jackknife crashes.

"I'm all about saving lives," Lawrence said. "I'm just terribly upset by what happened. This has been an absolute nightmare."

Explore further: Groups seek electronic collision alert devices on big trucks

Related Stories

US probes second suspected Tesla Autopilot crash

July 6, 2016

US highway safety officials said Wednesday that they are investigating a second crash of a Tesla car that may have been operating on the vehicle's pioneering self-drive Autopilot technology.

Automakers agree to put automatic braking in cars by 2022

March 17, 2016

Automatic braking will be standard in most cars and light trucks within six years and on heavier SUVs and pickup trucks within eight years under an agreement that transportation officials and automakers announced on Thursday.

Chevrolet helps customers put the brakes on rear crashes

January 19, 2015

Tailgating is great before football games, but in traffic, not so much. Rear-end crashes make up more than one in four of collisions reported to police each year, according to the National Highway Traffic Safety Administration ...

US ends probe of Tesla fatal crash without seeking recall

January 19, 2017

Tesla Motors Inc. won't face a recall or fine as a result of a fatal crash involving its Autopilot system, but U.S. safety regulators are warning auto manufacturers and drivers not to treat semiautonomous cars as if they ...

Recommended for you

Pushing lithium ion batteries to the next performance level

December 13, 2018

Conventional lithium ion batteries, such as those widely used in smartphones and notebooks, have reached performance limits. Materials chemist Freddy Kleitz from the Faculty of Chemistry of the University of Vienna and international ...

Uber filed paperwork for IPO: report

December 8, 2018

Ride-share company Uber quietly filed paperwork this week for its initial public offering, the Wall Street Journal reported late Friday.

1 comment

Adjust slider to filter visible comments by rank

Display comments: newest first

Nik_2213
not rated yet Jul 30, 2017
You DON'T have side-guards ?? Euro-zone companies figured how to do this without significant weight penalties decades ago...

Please sign in to add a comment. Registration is free, and takes less than a minute. Read more

Click here to reset your password.
Sign in to get notified via email when new comments are made.