NASA rigs up snorkel in spacesuit after risky water leak

Dec 18, 2013 by Kerry Sheridan
US astronaut Michael Hopkins waves on September 26, 2013 before the launch of a Soyuz-FG rocket at the Russian-leased Baikonur cosmodrome in Kazakhstan

Snorkels in space? NASA dreamed up the idea as a quick fix to a dangerous spacesuit problem so astronauts can step out to repair an equipment breakdown at the International Space Station.

One of the two US astronauts preparing to embark on a series of spacewalks later this week and next will be wearing an American-made suit that had a helmet leak in July, nearly drowning the European astronaut who wore it.

The three emergency spacewalks are planned for December 21, 23 and 25 in order to fix a broken cooling system at the orbiting outpost.

An investigation into the cause of the leak that flooded Italian astronaut Luca Parmitano's helmet and forced him to rush back inside the station in July is still ongoing, NASA officials told reporters Wednesday.

Therefore, faced with an unexpected valve failure last week in the system that regulates the temperature of equipment aboard the 15-year-old orbiting outpost, NASA engineers had to scramble to figure out a way to make the US spacesuits safe for use.

First off, they have replaced the water pump system in the suit Parmitano wore.

In addition, an extra helmet absorption pad has been installed at the inside back of the helmet to soak up any potential leak, and a snorkel has been rigged up to offer another breathing route if needed.

"Some smart engineers on the ground were able to figure out, 'Hey this is a similar diameter to a snorkel that you have for scuba diving,'" said NASA lead spacewalk officer Allison Bolinger.

"By just sacrificing one of our spares on board they were able to come up with a way to just snip off the ends and then file it so it is not rough in the crew member's mouth and then apply Velcro."

American astronaut Mike Hopkins will be wearing the suit Parmitano wore. Both he and fellow US astronaut Rick Mastracchio will have the new snorkels and pads inside their spacesuits as a safety measure.

Their task is to remove the pump module with the faulty valve and replace it with a spare pump that was already aboard the ISS.

Even though the formal investigation into the leaking helmet has not been completed, NASA officials said they were confident that their back-up solutions would allow the astronauts to be safe on their risky outings.

"We had this failure where we flooded the suit," said Mike Suffredini, manager of the International Space Station program, adding that the breakdown took NASA by surprise.

Engineers had thought if such a failure happened, the suit would shut down and the astronaut would be alerted of a 30-minute deadline to get back inside the station, he said.

An extensive review has since been done of all the hazards involved with the suits, which are 35 years old, Suffredini told reporters.

"Based on what we have learned, I would expect that for as long as we have this particularly designed suit, we will keep this pad and snorkel available to the crew."

Dina Contella, International Space Station flight director said the suit Hopkins will be wearing has a brand new fan pump separator and all the water lines and other components have also been changed.

"We feel confident that this suit is a very clean and ready to go," she told reporters.

Explore further: Video gives astronaut's-eye view inside NASA's Orion spacecraft

add to favorites email to friend print save as pdf

Related Stories

NASA sees 'some success' with space station fix

Dec 16, 2013

NASA engineers are still trying to fix an International Space Station cooling problem and have not yet decided whether spacewalks will be necessary, the US space agency said Monday.

NASA orders urgent spacewalk repairs at station

Dec 17, 2013

NASA has ordered up a series of urgent spacewalks to fix a broken cooling line at the International Space Station, a massive repair job that could stretch to Christmas Day.

NASA rolls out rocket for Thursday's ISS cargo launch

Dec 17, 2013

With the space station cooling system hobbled and a commercial cargo launch waiting in the wings, NASA Tuesday prepared all options but said no decision had yet been made on whether spacewalk repairs would ...

NASA: Cooling pump on space station shuts down

Dec 12, 2013

NASA said Wednesday it was looking into a problem with a malfunctioning cooling pump on the International Space Station, but there was no immediate danger to the two American astronauts, three Russian cosmonauts, ...

Recommended for you

SDO captures images of two mid-level flares

Dec 19, 2014

The sun emitted a mid-level flare on Dec. 18, 2014, at 4:58 p.m. EST. NASA's Solar Dynamics Observatory, which watches the sun constantly, captured an image of the event. Solar flares are powerful bursts ...

Why is Venus so horrible?

Dec 19, 2014

Venus sucks. Seriously, it's the worst. The global temperature is as hot as an oven, the atmospheric pressure is 90 times Earth, and it rains sulfuric acid. Every part of the surface of Venus would kill you ...

Image: Christmas wrapping the Sentinel-3A antenna

Dec 19, 2014

The moment a team of technicians, gowned like hospital surgeons, wraps the Sentinel-3A radar altimeter in multilayer insulation to protect it from the temperature extremes found in Earth orbit.

Video: Flying over Becquerel

Dec 19, 2014

This latest release from the camera on ESA's Mars Express is a simulated flight over the Becquerel crater, showing large-scale deposits of sedimentary material.

User comments : 6

Adjust slider to filter visible comments by rank

Display comments: newest first

Doug_Huffman
not rated yet Dec 18, 2013
Snorkel? The name is clearly not the thing, because a snorkel depends on gravity and buoyancy to function.
TheGhostofOtto1923
1 / 5 (1) Dec 18, 2013
Snorkel? The name is clearly not the thing, because a snorkel depends on gravity and buoyancy to function.
Only because thy have been used exclusively here on earth. They are intended to allow breathing while submerged by extending a tube into a place where there is air.
Mayday
4 / 5 (1) Dec 19, 2013
Did he mean to say that the suits are thirty-five years old? Or just the design? In either case: someone almost drowned in that very suit, investigation is still ongoing, jury-rigged and untried snorkel velcroed in place ... Would you take that suit for a stroll? I'm imagining being outside, deaf, dumb, and blind due to the water and the snorkel. Not good.
Though I am surprised that there wasn't always a mouthpiece breather -- mostly in case of depressurization -- to buy some time.
TheGhostofOtto1923
1 / 5 (1) Dec 19, 2013
Though I am surprised that there wasn't always a mouthpiece breather -- mostly in case of depressurization -- to buy some time
They probably figured that loss of air meant loss of pressure and you would be dead within 15 seconds anyway.
GSwift7
5 / 5 (1) Dec 20, 2013
The idea of water inside the helmet is really terrifying. In zero G, it wouldn't need to fill the whole helmet. It would only take a little bit of water floating around to interfere with your breathing, and there's no way to wipe it away. You could shake your head around, but you'd be bound to inhale some water into your nose. I can see how panick would be a problem for most people pretty fast.

(this post should be read with background music, preferably "Every Breath You Take", by the Police)
adam_russell_9615
not rated yet Dec 22, 2013
How does a snorkel work in zero gravity? Do you have a pocket of air with a water filter around it?

Please sign in to add a comment. Registration is free, and takes less than a minute. Read more

Click here to reset your password.
Sign in to get notified via email when new comments are made.