This article has been reviewed according to Science X's editorial process and policies. Editors have highlighted the following attributes while ensuring the content's credibility:


peer-reviewed publication

trusted source


Crystal phase-dependent activity of mnGaOx observed in direct syngas to light olefins

Crystal phase-dependent activity of mnGaOx observed in direct syngas to light olefins
Crystal-phase-dependent of syngas conversion activity of MnGaOx-SAPO-18. Credit: Bai Bing and Jiao Feng

Two notable metal oxide structures, spinel-type oxide and solid solution-type oxide, are widely used in Oxide-Zeolite (OXZEO) bifunctional catalysts for CO/CO2 hydrogenation reactions.

Identifying the crystallographic structure sensitivity of catalysts in is helpful to the rational design of catalysts. However, direct and convincing study to correlate the crystal structure of to its catalytic performance has yet to be done.

Recently, a joint research team led by Prof. Bao Xinhe, Prof. Pan Xiulian, Assoc. Prof. Jiao Feng and Prof. Xiao Jianping from the Dalian Institute of Chemical Physics (DICP) of the Chinese Academy of Sciences (CAS) has observed strong crystal phase-dependent activity of MnGaOx in direct syngas conversion. This study was published in Angewandte Chemie International Edition on April 18.

"The main challenge to observing the crystal structure of oxide is the lack of a well-defined material-synthesis method to obtain metal oxides with the same element components but different crystallographic structures," said Jiao.

In this study, the researchers found co-precipitation method and hydrothermal method could synthesize bimetallic oxides, which were composed of amorphous MnO2 and Ga2O3 with hexagonal close-packed (HCP) or Face centered-cubic (FCC) crystal phase, respectively. More interestingly, they found that the HCP oxide remained unchanged as HCP MnO-Ga2O3 solid solution oxides after reduction under H2 or CO, while the FCC solid solution oxide transformed into FCC spinel structure, where reduced Mn2+ took the A-site of AB2O4 spinel structure.

They obtained 40% CO conversion, 81% light olefins selectivity, and 0.17 g·gcat-1·h-1 space-time yield of light olefins with the combination of FCC MnGaOx-Spinel and SAPO-18. In comparison, they obtained a much inferior activity with solid solution MnGaOx with a similar chemical composition.

They further proved that the superior activity of MnGaOx-Spinel was attributed to its higher reducibility and the presence of coordinatively unsaturated Ga3+ site, which facilitated the dissociation of the C-O bond via a more efficient ketene-acetate pathway to light olefins.

"Our findings may further optimize for OXZEO syngas conversion," said Prof. Pan.

More information: Bing Bai et al, Tuning the Crystal Phase to Form MnGaOx‐Spinel for Highly Efficient Syngas to Light Olefins, Angewandte Chemie International Edition (2023). DOI: 10.1002/anie.202217701

Citation: Crystal phase-dependent activity of mnGaOx observed in direct syngas to light olefins (2023, April 28) retrieved 25 September 2023 from
This document is subject to copyright. Apart from any fair dealing for the purpose of private study or research, no part may be reproduced without the written permission. The content is provided for information purposes only.

Explore further

Synergistic interplay mechanism of dual active sites on bimetallic oxide for syngas conversion


Feedback to editors