New alternative to whey protein in calf milk replacers

July 14, 2017
New alternative to whey protein in calf milk replacers
Whey protein in calf milk replacers can be replaced with spray dried plasma protein. Credit: University of Illinois

We see a lot of whey protein on the supermarket shelves these days. The high-protein, low-carb diet trend has been highly profitable for cheese makers and whey processors, who once used the cheese byproduct as fertilizer or in animal feed. With more whey going to the human market, animal feed manufacturers are looking for alternative protein sources that maintain animal health while saving costs.

"Since is the major milk component that goes into milk replacers, it's the most expensive nutrient ingredient in the formula. There's long been a search to find alternatives that the very young calf can tolerate and grow well on without allergy problems or poor digestibility," says Jim Drackley, dairy nutritionist in the Department of Animal Sciences at the University of Illinois.

In a recent study, Drackley and graduate student Sarah Morrison may have found a near-ideal replacement for whey in calf milk replacers: spray-dried , supplemented with amino acids threonine and isoleucine. "In previous studies, we've found is well tolerated when replacing up to a third or a half of the whey protein in milk replacers. There are some limitations in the amino acid profile relative to the ideal protein, though. We wanted to see if we could improve performance by adding those back," he explains.

The research team fed milk replacer to preweaned calves from birth to eight weeks. Calves were either fed standard whey-based milk replacer with methionine, or milk replacer with methionine and a portion of the whey replaced with plasma protein (5 or 10 percent). In addition to methionine, half of the plasma protein formulations were also supplemented with threonine and isoleucine.

Over the eight-week study, the calves were evaluated for growth and health status. Overall, calves that were fed plasma protein plus the did just as well as those that were fed standard milk replacer. Without threonine and isoleucine, however, calves that received the higher level of plasma protein did not perform as well.

The results indicate that plasma protein can be used to replace a large portion of whey in milk replacers as long as the amino acid profile is maintained similar to whey proteins. This is good news for those looking to cut costs on farm. "Plasma protein is more expensive than some other sources like soy proteins, but it can be economical compared to whey," Drackley says.

The benefits of plasma proteins don't end there. Drackley points to health improvements in the calves that were fed the plasma diets, including lowered rates of diarrhea. "Plasma proteins contain immunoglobulins that have positive effects on the immune system and antimicrobial effects in the animal. The spray-drying process preserves those so they still have some activity in the digestive tract," he says.

Drackley points out that alternative nutrient sources in often get a bad rap as byproducts. Instead, he says, we should celebrate the cow's ability to recycle products humans can't eat, turning them into wholesome and nutritious foods we can.

The article, "Amino acid supplementation of calf replacers containing plasma protein," is published in the Journal of Dairy Science.

Explore further: New study deems dairy 'excellent' source of protein for children

More information: S.Y. Morrison et al. Amino acid supplementation of calf milk replacers containing plasma protein, Journal of Dairy Science (2017). DOI: 10.3168/jds.2016-12402

Related Stories

Re-thinking waste from yogurt production

September 22, 2016

It takes four kilograms of milk to make just one kilogram of Greek yogurt. That means a lot of natural nutrients from milk are not readily being captured and Australians consume a lot of Greek yogurt.

Dairy study in top agriculture journal

May 30, 2013

Massey University researcher Dr Jean Margerison has had a research article accepted for publication in the prestigious Journal of Dairy Science.

Recommended for you

Even wild mammals have regional dialects

December 13, 2017

Researchers from Cardiff University's Otter Project have discovered that genetically distinct populations of wild otters from across the UK have their own regional odours for communicating vital information to each other. ...

Mosquito sex protein could provide key to controlling disease

December 13, 2017

If you thought the sex lives of humans were complicated, consider the case of the female Aedes aegypti mosquito, bringer of Zika, dengue, and yellow fever: She mates but once, in seconds and on the wing, with one lucky male; ...

Defence at almost any price

December 13, 2017

Even bacteria have enemies – in water, for example, single-celled ciliates preferably feed on microbes. The microbes protect themselves against predators by employing a variety of tricks, which the ciliates, in turn, attempt ...

0 comments

Please sign in to add a comment. Registration is free, and takes less than a minute. Read more

Click here to reset your password.
Sign in to get notified via email when new comments are made.