Don't let VW scandal destroy your faith in car industry

Don’t let VW scandal destroy your faith in car industry

The Volkswagen emissions scandal has shattered trust in the automotive industry the world over. After news broke that VW had knowingly circumvented US emissions regulations, shares in a number of car companies took a hit, while other regulators launched investigations of their own, finding similar breaches.

It has been hugely damaging to consumer confidence. In fact, it seems that a majority of consumers are now sceptical about the environmental claims made by any car manufacturer – whether they cheated the tests or not.

But as VW continues to suffer the consequences of its deception, there's no reason to tar the whole industry with the same brush. In fact, doing so could lead to the introduction of regulations that are too tough, too soon – and this would risk stalling progress on emissions altogether.

Lab vs life

The fact is, all vehicles perform much better in laboratory tests than in real life. This means that there has always been a difference between a vehicle's emissions levels in the lab – which are used to ensure that legal requirements are met – and those it produces during day to day use. The data which points to these discrepancies has been in the public domain for many years.

Part of the problem is that it's very difficult to mimic real life conditions in the lab. The type approval test we use today was designed three decades ago by the EU in consultation with the industry, to deliver a precise benchmark for system performance.

But back then, the technology used to test vehicles could not fully and accurately represent the dynamics of driving. Real driving is much more aggressive and varied than testing technologies could then account for reliably. The tests must measure in a robust and repeatable manner. And while the tools we use for testing have developed enormously over the years, the challenge to be ever more dynamic and accurate still persists.

Don’t let VW scandal destroy your faith in car industry
Put to the test. Credit: University of Bath, Author provided

So, regulatory tests were never intended to be a predictor of real world behaviour. Rather, they are an incredibly useful tool for ranking and comparing technologies, vehicles or manufacturers, and have proven very effective at driving technological change. For example, tests which revealed the effectiveness of the diesel particulate filter – a device which removes soot from exhaust fumes – led to their uptake right across Europe by the late-2000s.

Progress like this comes about by maintaining a delicate balance between the realities of the car industry, and the environmental and public health aims of the regulators.

A most demanding business

As a result of this process, the EU Technical Committee for Motor Vehicles recently agreed to introduce recently developed real driving emissions (RDE) tests for diesel cars. This is part of the latest set ofregulations – called EU6 – which marks the largest ever revision to .

The RDE requirements will introduce on-road emissions measurements for the first time, with initial real world emissions limits set 2.1 times higher than the lab-based limits. This should make it impossible for any company to subvert the process in the way it seems VW has. And it means that discrepancies between lab and real driving performance will be clearly reported. Even so, the measures were still less severe than some were expecting.

Yet meeting them will still present a significant hurdle for the industry. Car makers operate in one of the most demanding of all business environments, and automotive engineers have to resolve the complex trade-offs that are inevitable between legal requirements, customer preference, innovation, cost and fuel efficiency.

It's crucial that the targets set by regulators are achievable, under these circumstances. If they are not, it would seriously damage the commercial viability of car companies. And this would lead to an economic and social fallout too huge to consider: I am from Coventry – the home of the British motor industry – and old enough to have seen the damage caused by the loss of so many of the great companies that once built cars in the city.

The next step

Over the past 25 years, regulations in the EU have evolved to see real world emissions from petrol and diesel engines fall dramatically – in many cases by a factor of around 100.

One important exception to this trend is the level of nitrogen oxides (NOx) in emissions from diesel passenger cars. NOx – the most intractable of all emissions for diesel engines – was at the centre of the emissions scandal. But until very recently, it was also the pollutant with the least robust evidence of negative health impacts. For this reason, it was not a high priority target for regulators, compared with particulates, unburnt hydrocarbons and deadly carbon monoxide emissions.

But today, the effective elimination of these other emissions from modern passenger cars, and the attention warranted by VW's behaviour, has cleared the way to focus on the NOx issue. The introduction of EU6 and RDE requirements will undoubtedly promote the adoption of technologies that work well in the real world. In fact, several diesel cars currently on sale in Europe already meet the future regulations.

Automotive engineers can now focus on what is really important for the customer, rather than meeting an outdated approval test. Addressing NOx , improving air quality and reducing CO₂ will be the order of the day. So, despite the VW scandal continuing to unfold, consumers have more cause for optimism than suspicion.

Explore further

98,000 petrol cars hit in VW's CO2 emissions scandal: minister

This story is published courtesy of The Conversation (under Creative Commons-Attribution/No derivatives).
The Conversation

Citation: Don't let VW scandal destroy your faith in car industry (2015, November 30) retrieved 26 June 2019 from
This document is subject to copyright. Apart from any fair dealing for the purpose of private study or research, no part may be reproduced without the written permission. The content is provided for information purposes only.

Feedback to editors

User comments

Nov 30, 2015
I don't know what all the fuss is about. More than half of the worlds biomass nitrogen has been fixed due to the Haber process. It has doubled life and food. A diffuse and continuous bleed of NOx into the atmosphere is a good thing.
I for one welcome VW's new crowdsourced self-funded nitrogen-fixation units.

Nov 30, 2015
In fact, doing so could lead to the introduction of regulations that are too tough, too soon – and this would risk stalling progress on emissions altogether.

How exactly could tougher regulations stall progress on emissions? I must be missing something, here.

Part of the problem is that it's very difficult to mimic real life conditions in the lab.

The obvious solution (and the one that brought this scandal to light) is: Don't test in the lab (and don't let auto makers test their own products). It's not like this is infeasible.
It's all nice and dandy that we can get comparable lab tests results between cars, but in the end cars aren't driven in the lab - so the advantage of buying by "better lab-results" to the consumer is nil.

Please sign in to add a comment. Registration is free, and takes less than a minute. Read more