Green Power from Chicken Litter

July 15, 2005

Gas Technology Institute (GTI) has successfully demonstrated that chicken litter can be gasified to produce hydrogen and generate electricity using a solid oxide fuel cell (SOFC). Under a project funded by the U.S. Department of Agriculture, Earth Resources, Inc. (prime contractor), GTI, and the University of Georgia are working to convert chicken litter into energy and fertilizer. As part of this USDA-funded project, GTI conducted a test to demonstrate the suitability of chicken litter as a low-Btu fuel for the SOFC.

Litter from poultry farms is traditionally used in land applications as a fertilizer because it is rich in nutrients. But the rise in poultry production combined with the decreasing availability of land and potential deleterious environmental impacts creates concern about traditional litter disposal methods. Gasification has the potential to provide a cost-effective, environmentally benign disposal option for the litter while providing heat, power, fuel (such as hydrogen) and fertilizer.

According to Francis Lau, Director of Corporate Development at TI, “Commercialization and implementation of such a modular technology has the potential to generate on-site power and heat from a renewable source of energy economically while addressing environmental problems caused by traditional disposal practices. Also, chicken litter can replace fossil fuels currently used to provide heat in poultry farms, thus avoiding net generation of CO2. GTI is pursuing the development and commercialization of this technology.”

The fuel gas was produced in a bench-scale fluidized bed gasifier operated at 1550°F with the chicken litter feed. Air and steam were used as the gasifying medium. A 5-cell SOFC stack was operated at 1470°F on the slipstream from the gasifier. A zinc oxide (ZnO)-based sorbent bed was used to remove H2S in the fuel gas prior to entering the SOFC stack. An average power density is about 40% of that obtained from reformed natural gas due to this low-Btu (80 Btu/ft3) fuel. Post-test disassembly confirmed no carbon deposition on the SOFC nickel anode and did not indicate any unusual state of the stack active components.

GTI is the leading research, development and training organization serving the natural gas industry and energy markets. For more than 60 years, GTI has been meeting the nation's energy and environmental challenges by developing technology-based solutions for consumers, industry, and government.

Source: Gas Technology Institute

Explore further: Fowl play as scientists make power from chicken droppings

Related Stories

Fuel to the fire? Fuel exports soar under Obama

December 8, 2014

Solar panels glisten from every thatched hut on this crowded island, one of the largest in this remote chain off the Panamanian coast. But the tiny emblems of green energy offer no hope against climate change.

Recommended for you

The Swiss army knife of smoke screens

March 18, 2018

Setting off smoke bombs is more than good fun on the Fourth of July. The military uses smoke grenades in dangerous situations to provide cover for people and tanks on the move. But the smoke arms race is on. Increasingly, ...

World's biggest battery in Australia to trump Musk's

March 16, 2018

British billionaire businessman Sanjeev Gupta will built the world's biggest battery in South Australia, officials said Friday, overtaking US star entrepreneur Elon Musk's project in the same state last year.

Plasmons triggered in nanotube quantum wells

March 16, 2018

A novel quantum effect observed in a carbon nanotube film could lead to the development of unique lasers and other optoelectronic devices, according to scientists at Rice University and Tokyo Metropolitan University.


Please sign in to add a comment. Registration is free, and takes less than a minute. Read more

Click here to reset your password.
Sign in to get notified via email when new comments are made.