Cattle fed distiller's grains maintain flavor and tenderness of beef

Oct 22, 2008

The availability and use of wet distiller's grains in beef finishing diets continues to increase as the ethanol industry expands, and some Texas AgriLife Research scientists are trying to determine if that will affect consumers' meat purchases.

While much of the research focus has been on the energy value of the distiller's grains relative to the corn it replaces, recent questions have been posed on how they may affect beef quality, said Dr. Jim MacDonald, AgriLife Research ruminant nutritionist.

The concern is based on the premise that replacing corn, which is primarily starch, with distiller's grains, which has essentially no starch, will reduce blood glucose and negatively impact the marbling of beef cuts, MacDonald said.

MacDonald and others conducted a study funded by the $1-per-head beef checkoff, Texas Beef Council, and a cooperative agreement between the U.S. Department of Agriculture-Agriculture Research Service and AgriLife Research.

In the study, 54 steers were fed dry-rolled corn or steam-flaked corn-based finishing rations with or without 35 percent wet distiller's grain, he said. The goal was to determine the effects of the corn processing and the inclusion of distiller's grain on marbling attributes, sensory attributes and shelf-life of beef loins.

The final data indicated that feeding 35 percent wet distiller's grains in both of the finishing diets may decrease the shelf-life of beef, but likely will have little impact on beef taste and quality, MacDonald said.

In the study, a single one-inch thick steak was removed from the 13th rib end of the loin from each animal, MacDonald said. The steaks were vacuum-packaged and aged for 14 days prior to freezing.

Sensory analysis was performed at Texas A&M University with trained panelists. The beef was judged for palatability attributes such as juiciness, tenderness and flavor.

"When you add distiller's grains to steam-flaked corn-based diets, it does not negatively affect palatability attributes," MacDonald said. "In fact, our panel found those steaks with distiller's grains to be slightly more tender."

The results indicate that the corn-processing method affects sensory properties of steaks; but while consistent, the differences were minimal, MacDonald said.

Sensory differences also were detected in steaks from steers fed differing levels of dietary wet distiller's grain plus solubles; however, the differences were slight, MacDonald said. It is unknown if the levels detected by expert, trained sensory panelists would be detected by consumers.

Another finding of this study was that distiller's grain byproducts increased the muscle concentration of linoleic acid, said Dr. Stephen Smith, AgriLife Research professor of animal science at Texas A&M University.

Increasing the concentration of linoleic acid in beef makes it more susceptible to producing a warmed-over flavor if it is stored in the refrigerator after cooking, Smith said.

The addition of distiller's grain byproducts to finishing altered the activity of enzymes important in the deposition of marbling fat also, he said. As a result, beef from cattle fed distiller's grain byproducts was higher in saturated and trans-fatty acids, and lower in the monounsaturated fatty acid, oleic acid, than beef from cattle not fed distiller's grains.

Smith said even though palatability attributes were not affected by distiller's grain byproducts, the composition of the beef changed quite a bit.

Steaks from steers fed distiller's grains may be darker in color and were more susceptible to lipid oxidation after five days of storage, MacDonald said.

But incorporation of wet distiller's grains into steam-flaked corn-based diets does not appear to affect beef quality differently than incorporation into dry-rolled corn-based diets, he said.

These results indicate that feeding wet distiller's grains to feedlot cattle may impact the shelf-life of beef, but likely has minimal effects on beef taste and quality, MacDonald said.

Source: Texas A&M AgriLife Communications

Explore further: Activists urge EU to scrap science advisor job

add to favorites email to friend print save as pdf

Related Stories

Saturated fats do not yield better bacon

May 28, 2013

A recent paper published in the Journal of Animal Science suggests producers may want to adjust pig diets when including distillers dried grains with solubles (DDGS). Some producers believe that feeding pigs saturated fats w ...

The lifetime journeys of manure-based microbes

Feb 22, 2013

Studies at the U.S. Department of Agriculture (USDA) are shedding some light on the microbes that dwell in cattle manure—what they are, where they thrive, where they struggle, and where they can end up.

Fueling ethanol production while protecting water quality

Apr 01, 2008

Grain-based ethanol production has increased dramatically in recent years as the cost and instability of oil has increased. New U.S. government policies require major increases in ethanol production. While future plans call ...

Recommended for you

Activists urge EU to scrap science advisor job

18 hours ago

Nine major charities urged the European Commission on Tuesday to scrap a science advisor position it says puts too much power over sensitive policy into the hands of one person.

More to a skilled ear in music

Aug 15, 2014

The first pilot study in Australia to give musicians the skills and training to critically assess music by what they hear rather than what they see begins this month at the Sydney Conservatorium of Music.The study aims to ...

User comments : 1

Adjust slider to filter visible comments by rank

Display comments: newest first

Soylent
not rated yet Oct 23, 2008
Corn ethanol is a terrible waste of farmland and energy and grain-fed beef is no match for lean, grass-fed beef with a healthier fat composition.