Inflatable antennae could give CubeSats greater reach

Sep 06, 2013 by Jennifer Chu
View of a CubeSat equipped with an inflated antenna, in a NASA radiation chamber. Credit: Alessandra Babuscia

The future of satellite technology is getting small—about the size of a shoebox, to be exact. These so-called "CubeSats," and other small satellites, are making space exploration cheaper and more accessible: The minuscule probes can be launched into orbit at a fraction of the weight and cost of traditional satellites.

But with such small packages come big limitations—namely, a satellite's communication range. Large, far-ranging are impossible to store in a CubeSat's tight quarters. Instead, the satellites are equipped with smaller, less powerful antennae, restricting them to orbits below those of most geosynchronous satellites.

Now researchers at MIT have come up with a design that may significantly increase the communication range of small satellites, enabling them to travel much farther in the : The team has built and tested an inflatable antenna that can fold into a compact space and inflate when in .

The antenna significantly amplifies a , allowing a CubeSat to transmit data back to Earth at a higher rate. The distance that can be covered by a satellite outfitted with an inflatable antenna is seven times farther than that of existing CubeSat communications.

"With this antenna you could transmit from the moon, and even farther than that," says Alessandra Babuscia, who led the research as a postdoc at MIT. "This antenna is one of the cheapest and most economical solutions to the problem of communications."

Babuscia and her colleagues, from MIT's departments of Aeronautics and Astronautics and of Earth, Atmospheric and Planetary Sciences, have detailed their results in the journal Acta Astronautica.

'Magic' powder

An inflatable antenna is not a new idea. In fact, previous experiments in space have successfully tested such designs, though mostly for large satellites: To inflate these bulkier antennae, engineers install a system of pressure valves to fill them with air once in space—heavy, cumbersome equipment that would not fit within a CubeSat's limited real estate.

Babuscia raises another concern: As small satellites are often launched as secondary payloads aboard rockets containing other scientific missions, a satellite loaded with pressure valves may backfire, with explosive consequences, jeopardizing everything on board. This is all the more reason, she says, to find a new inflation mechanism.

The team landed on a lighter, safer solution, based on sublimating powder, a chemical compound that transforms from a solid powder to a gas when exposed to low pressure.

"It's almost like magic," Babuscia explains. "Once you are in space, the difference in pressure triggers a chemical reaction that makes the powder sublimate from the solid state to the gas state, and that inflates the antenna."

Testing an inflating idea

Babuscia and her colleagues built two prototype antennae, each a meter wide, out of Mylar; one resembled a cone and the other a cylinder when inflated. They determined an optimal folding configuration for each design, and packed each antenna into a 10-cubic-centimeter space within a CubeSat, along with a few grams of benzoic acid, a type of sublimating powder. The team tested each antenna's inflation in a vacuum chamber at MIT, lowering the pressure to just above that experienced in space. In response, the powder converted to a gas, inflating both antennae to the desired shape.

The group also tested each antenna's electromagnetic properties—an indication of how well an antenna can transmit data. In radiation simulations of both the conical and cylindrical designs, the researchers observed that the cylindrical antenna performed slightly better, transmitting data 10 times faster, and seven times farther, than existing CubeSat antennae.

An antenna made of thin Mylar, while potentially powerful, can be vulnerable to passing detritus in space. Micrometeroids, for example, can puncture a balloon, causing leaks and affecting an antenna's performance. But Babuscia says the use of sublimating powder can circumvent the problems caused by micrometeroid impacts. She explains that a sublimating powder will only create as much gas as needed to fully inflate an antenna, leaving residual powder to sublimate later, to compensate for any later leaks or punctures.

The group tested this theory in a coarse simulation, modeling the inflatable antenna's behavior with different frequency of impacts to assess how much of an antenna's surface may be punctured and how much air may leak out without compromising its performance. The researchers found that with the right sublimating powder, the lifetime of a CubeSat's inflatable antenna may be a few years, even if it is riddled with small holes.

Babuscia says future tests may involve creating tiny holes in a prototype and inflating it in a vacuum chamber to see how much powder would be required to keep the antenna inflated. She is now continuing to refine the design at JPL.

"In the end, what's going to make the success of CubeSat communications will be a lot of different ideas, and the ability of engineers to find the right solution for each mission," Babuscia says. "So inflatable antennae could be for a spacecraft going by itself to an asteroid. For another problem, you'd need another solution. But all this research builds a set of options to allow these spacecraft, made directly by universities, to fly in deep space."

Explore further: "CanJam" joint among first to fly on NASA, Virgin Galactic flight

Related Stories

Zone of silence: Testing satellite antennas

Apr 12, 2013

( —Satellite engineers learn to get used to the weirdly hushed interior of the Compact Payload Test Range in ESA's ESTEC technical centre area, in Noordwijk, the Netherlands. In this zone of silence, ...

NASA announces new CubeSat space mission candidates

Feb 27, 2013

NASA has selected 24 small satellites, including three from NASA's Jet Propulsion Laboratory in Pasadena, Calif., to fly as auxiliary payloads aboard rockets planned to launch in 2014, 2015 and 2016. The ...

New breed of satellites

Jun 25, 2013

( —These pictures give the first detailed views of the next batch of Galileo satellites, the first of which has already been delivered to ESA for rigorous testing in simulated space conditions.

Gaia checks out of antenna testing

Jul 03, 2012

( -- Entombed by the distinctive foam pyramids typical of test chambers, the main antenna of the Gaia billion-star surveyor has been put through its paces ahead of launch next year.

Russian spaceship may fail to dock to ISS

Apr 25, 2013

An unmanned Russian spaceship carrying 2.5 tonnes of cargo may be unable to properly dock with the International Space Station after its navigation antenna failed to properly deploy, Interfax said on Thursday. ...

Recommended for you

NASA's IceCube no longer on ice

2 hours ago

NASA's Science Mission Directorate (SMD) has chosen a team at NASA's Goddard Space Flight Center in Greenbelt, Maryland, to build its first Earth science-related CubeSat mission.

Tidal forces gave moon its shape, according to new analysis

17 hours ago

The shape of the moon deviates from a simple sphere in ways that scientists have struggled to explain. A new study by researchers at UC Santa Cruz shows that most of the moon's overall shape can be explained by taking into ...

User comments : 0