Researchers find that some 'green' hot water systems fail to deliver on promises

May 02, 2013

Two researchers affiliated with the Virginia Tech College of Engineering have published a paper which reports that hot water recirculating systems touted as "green," actually use both more energy and water than their standard counterparts.

Marc Edwards, the Charles P. Lunsford Professor of Civil and Environmental Engineering in the Virginia Tech College of Engineering, originated the efficiency study of the systems as part of an undergraduate design class six years ago. After a thorough analysis, the class concluded the claims as false, and that it "was thermodynamically impossible for these systems to save as claimed," said Edwards.

The topic was selected as part of a dissertation by Randi Brazeau during her doctorate in Virginia Tech's Charles E. Via Jr. Department of Civil and Environmental Engineering. The results are presented in a paper published in the most recent issue of Journal of Green Building.

Brazeau, now an assistant professor of at Metropolitan State University of Denver, examined the energy and of continuous hot recirculating systems in a comparative, direct test versus traditional hot water systems in which consumers often wait for the cold water to flush down the drain before the water warms to a comfortable temperature for showering.

She found that the recirculation systems used 20 percent more energy even in the best possible scenario in which the water pump was only on for a few seconds before use, and in scenarios where the pump was always on, the recirculation systems could require more than double the energy to operate. The consumer pays for this extra energy in higher electric and fuel bills.

"Randi demonstrated that when all are accounted for, including that necessary to run the pump, the hot water recirculating systems always used much more energy than the conventional systems," said Edwards.

A previous U.S. Department of Energy report and certain manufacturers claimed the recirculation devices would not only eliminate wait times, but also would save both water and energy. It also was assumed that because consumers did not need to wait for water to warm, the hot water recirculation systems would at minimum save water from being wasted. But that claim did not consider that it takes water to make energy, said Edwards.

The research found that the "so-called green" hot water recirculation systems used more net water than the conventional systems after accounting for water needed to produce the extra energy. "These are really consumer comfort and convenience devices, a luxury really, masquerading as 'green' or environmentally conscious devices," Edwards said.

Other findings: On-demand electric systems operate with nearly 100 percent energy efficiency, but cannot be used in many circumstances dependent on scaling and incoming water temperature, and may require expensive upgrades to home electrical systems and use of low or ultra-low flow showerheads.

In many cases, recirculating systems touted as "green" are not just a consumer choice, but required in some new homes and businesses in the United States, said Brazeau. But their energy savings, and therefore lessened environmental impact claimed by manufacturers "do not hold water," she added.

Brazeau and Edwards calculated that a typical consumer with an electric water heater would pay as much as $158 more annually compared to systems without recirculation. More research, though, is necessary to better inform policy and decision-making by regulators, public health officials, manufacturers, and consumers, Edwards and Brazeau said.

Explore further: Finalists named in Bloomberg European city contest

Related Stories

U.S. scientists develop better heat pump

Jan 18, 2007

U.S. homeowners might soon see their electric bills decreasing thanks to an integrated heat pump system developed by the Oak Ridge National Laboratory.

Recommended for you

US urged to drop India WTO case on solar

4 hours ago

Environmentalists Wednesday urged the United States to drop plans to haul India to the WTO to open its solar market, saying the action would hurt the fight against climate change.

Is nuclear power the only way to avoid geoengineering?

11 hours ago

"I think one can argue that if we were to follow a strong nuclear energy pathway—as well as doing everything else that we can—then we can solve the climate problem without doing geoengineering." So says Tom Wigley, one ...

Finalists named in Bloomberg European city contest

16 hours ago

Amsterdam wants to create an online game to get unemployed young people engaged in finding jobs across Europe. Schaerbeek, Belgium, envisions using geothermal mapping to give households personalized rundowns of steps to save ...

Bloomberg invests $5M in solar-powered lamp

Apr 22, 2014

Former New York Mayor Michael Bloomberg's foundation has announced a $5 million investment in an artsy-looking solar-powered lamp designed for use in off-grid populations in Africa.

User comments : 4

Adjust slider to filter visible comments by rank

Display comments: newest first

VENDItardE
2.3 / 5 (7) May 02, 2013
I am shocked that another green solution does not live up to its claims.
ormondotvos
2.5 / 5 (4) May 02, 2013
Solar water heaters are actually quite efficient.
Recirculating systems are a scam. If you want instant hot water, put the tank under the sink, next to the shower.
VendicarE
3 / 5 (2) May 03, 2013
I am not shocked that corrupt capitalists are lying to their customers and selling them shoddy products. This is the primary means by which they hoodwink the consumer.
.

"I am shocked that another green solution does not live up to its claims." - VendiTard
VendicarE
4.5 / 5 (2) May 03, 2013

"Recirculating systems are a scam." - Ormondo

The ones I have seen, yes that is the case.

However there can be some energy savings by pre-heating water that enters the water heater by having it make thermal contact with the hot waste water stream.

No pumping is needed of course since the input water stream is pushed by the building or city water system and the waste water stream by gravity.

Chinese water heaters work well and are of course a spectacular hit all over the world.

More news stories

US urged to drop India WTO case on solar

Environmentalists Wednesday urged the United States to drop plans to haul India to the WTO to open its solar market, saying the action would hurt the fight against climate change.