Biofuels research searches for new sources

August 3, 2006

The words are becoming familiar, even if the products aren't: biofuel, biobased, biodiesel, bioethanol. All refer to fuel that's made from bio-produced materials such as plants. Chengci Chen (pronounced Chen-see Chen), an assistant professor of cropping systems at the Central Agricultural Research Center at Moccasin, Mont., and his collaborators are investigating Montana's potential for producing biofuels using "biomass," which refers to all biologically produced materials like grains, straw, hay, trees and fruits. He and his collaborators are working on a project to evaluate the ethanol production potential of various straws, hays, and silages in Montana.

People can make fuel from many kinds of plants, though over 90 percent of ethanol made in the United States comes from corn grain. However, other sources of ethanol are needed, because even if the entire United States' corn crop was used for ethanol, it would meet only 10 percent of the country's fuel needs.

So researchers are looking for new sources for ethanol. Since the jury is still out on what combination of sources will be best to replace petrol, Chen is working with sources that will be more universally available -- especially in Montana.

Chen is working on the issue from two directions. First, he is looking at how to maximize the volume of Montana crops or their residues with less input. At the same time, he is looking for the most efficient enzyme to break down the biomass into sugars and also looking at microorganisms that can ferment the sugars into fuel.

Daniel Kammen, director of the Renewable and Appropriate Energy Lab at the University of California at Berkeley, said in a recent email that rapid technological advances in the production of such cellulosic ethanol are contributing to its tremendous potential as an easy-to-use fuel in conventional vehicles.

How best to bring that tremendous potential to Montana is just what Chen and his collaborators are researching.

"If we use grass and straw, you can find the stock everywhere," Chen said. "It is widely available in many regions of the country, rather than being limited to the Corn Belt, and it has the potential to have higher production in Montana."

The United States is facing increasing energy challenges. President Bush's proposal for additional clean-energy research in his State of the Union Address acknowledged the need for extensive research in biofuel, and the U.S. Department of Energy announced this month an ambitious research agenda for developing cellulosic ethanol. The Department of Energy called it in a news release "a renewable, cleaner-burning, and carbon-neutral alternative to gasoline" and "an economically viable transportation fuel."

"Montana farms produce 10 million tons of wheat and barley straw that are typically left in the field. An additional five million tons of hay are produced annually," said Dave Wichman, superintendent of the Central Ag Research Center "The advantage of using annual farm crops for ethanol production is that farmers can produce biomass with conventional crops and equipment, and can alternate crop production for energy, food or feed," he added.

In areas with irrigation and enough heat, a double-cropping system with winter cereals and warm season grasses like winter triticale and sweet sorghum, can be adopted.

"The biomass production increases by as much as 50 percent using this system compared to a single-cropping system," Chen explained. "Even perennial grasses like switchgrass might be grown on marginal lands or lands retired from the Conservation Reserve Program."

Chen is working with scientists at the Biological Engineering Department of North Carolina State University to screen chemicals and enzymes that pretreat and convert biomass into sugars.

"Biomass energy can contribute to cleaner air through reduction in greenhouse gas emissions. It can alsoimprove rural economies, and reduce energy dependence on foreign petroleum oils," said Ralph Peck, director of the Institute for Biobased Products at MSU. The institute has funded Chen's research after receiving a line-item appropriation through Sen. Conrad Burns, R-Mont.

"One of our goals is to make the new ethanol production methods from biomass competitive," Peck said.

Source: Montana State University

Explore further: Harnessing the power of waste

Related Stories

Harnessing the power of waste

August 5, 2015

What are you wearing right now? It's not a pickup line—it's a measure of your carbon footprint. If you're sporting any man-made fabrics, like polyester, Dacron or rayon, you're clothed in chemicals derived from nonrenewable ...

Why bacteria could be the answer to a future without oil

July 30, 2015

Chemicals are all around us. They are crucial in all manner of industries, from agriculture to food to cosmetics. Most people give little thought to how these chemicals are made – and certainly very few would consider the ...

Argonne works with marine industry on new fuel

July 30, 2015

The battle for cleaner, greener fuels isn't fought solely on land - America's rivers, lakes and surrounding seas are home to 17 million recreational boats keeping more than 75 million weekend warriors afloat each year.

Unlocking lignin for sustainable biofuel

July 7, 2015

Turning trees, grass, and other biomass into fuel for automobiles and airplanes is a costly and complex process. Biofuel researchers are working to change that, envisioning a future where cellulosic ethanol, an alcohol derived ...

Recommended for you

Customizing 3-D printing

September 3, 2015

The technology behind 3-D printing is growing more and more common, but the ability to create designs for it is not. Any but the simplest designs require expertise with computer-aided design (CAD) applications, and even for ...

Team develops targeted drug delivery to lung

September 2, 2015

Researchers from Columbia Engineering and Columbia University Medical Center (CUMC) have developed a new method that can target delivery of very small volumes of drugs into the lung. Their approach, in which micro-liters ...

Magnetic fields provide a new way to communicate wirelessly

September 1, 2015

Electrical engineers at the University of California, San Diego demonstrated a new wireless communication technique that works by sending magnetic signals through the human body. The new technology could offer a lower power ...

0 comments

Please sign in to add a comment. Registration is free, and takes less than a minute. Read more

Click here to reset your password.
Sign in to get notified via email when new comments are made.